A Study on the Economical Design of Protection Facilities through EXPLOSION TEST and Simulation
Military
Views. 1828
Abstract
Purpose: In this study, the possibility of economical design of a protective structure was presented based on explosion test data and computer simulation results on the safety of both a building and human bodies for the combat training building.Method: A training facility was built for soldiers to experience the vibration, pressure, and noise generated inside the building due to the explosion of the TNT. In the explosion proof test, 9lb of TNT, equivalent to the weight of a 4.2-inch mortar shell, was detonated in four places around the building, including the roof of the training building, the door, and the outside of the wall to determine the damage. Vibration, pressure and noise transmitted into the building were measured. After the explosion test, the damage to the building was examined through a rebound hardness test and visual inspection, and the impact on the human body was estimated by measuring the pressure at three spots inside the building. Afterwards, computer modeling and simulation was performed using High Explosion Damage & Injury Assessment Model(HExDAM) and simulation results were compared with explosion test measurements.
Results: As a result of inspecting the structural damage of the building, there was no significant displacement of the structure and it was determined that there was no problem in using the building. The compressive strength of concrete was observed through Schmidt hammer, it showed 96% of the strength compared to the design strength(30MPa). The pressure inside the building was measured in the range between 0.063 and 0.488 kPa, which is a very small value that is harmless to the human body. According to computer simulation, the internal pressure increased as the wall thickness decreased. However, even if the wall thickness was reduced, the pressure delivered to the inside did not increase significantly, and it was still found to be harmless to the human body.
Conclusion: Through the explosion test, it was confirmed that the structure and personnel inside the training building for combat field experience were safe enough against the explosive power of a 4.2-inch mortar shell. Computer simulations showed that there is room for reducing the thickness of the wall of the building, and the necessity of economical design was suggested by using computer simulation for designing protection facilities and military facilities.
[Keywords] Blast Effects, Explosion Test, Reinforced Concrete Building, HExDAM, Modeling & Simulation
References
[1] Kim J. Future Warfare and Artificial Intelligence Applications in the ROK Military: Problems and Alternatives. Robotics & AI Ethics, 6(2), 11-20 (2021). [Article]
[2] Johnson J. Artificial Intelligence & Future Warfare: Implications for International Security. Defense & Security Analysis, 35(2), 147-69 (2019).
[3] Sharma P & Sarma KK & Mastorakis NE. Artificial Intelligence Aided Electronic Warfare Systems-recent Trends and Evolving Applications. IEEE Access, 8, 224761-224780 (2020).
[4] Li Y & Cho H & Park G. The Advent of AI and Its Some Implications to Military Affairs. International Journal of Military Affairs, 5(1), 38-47 (2020). [Article]
[5] Helfer T & Jordan N & Lee R & Pietrusiak P & Cave K & Schairer K. Noise-induced Hearing Injury and Comorbidities among Postdeployment U.S. Army Soldiers: April 2003-June 2009. American Journal of Audiology, 20(1), 33-41 (2011).
[6] Samson K. Blast-related Eardrum Damage May Indicate Brain Injury, US Military Doctors in Iraq Report. Neurology Today, 7(18), 25-26 (2007).
[7] Myers PJ & Wilmington DJ & Gallun FJ & Henry JA & Fausti SA. Hearing Impairment and Traumatic Brain Injury among Soldiers: Special Considerations for the Audiologist. Seminars in Hearing, 30(1), 5-27 (2009).
[8] Jordan N & Lee R & Helfer T. Noise-induced Hearing Injury among Army Active Duty Soldiers Deployed to the Central Command Area of Operations. Seminars in Hearing, 30(1), 28-37 (2009).
[9] Van’t Wout MC & Van Dyk GA. Managing Morale on the Battlefield: A Psychological Perspective. Scientia Militaria: South African Journal of Military Studies, 43(1), 127-48 (2015).
[10] Park G & Seo E & Shin H. A New Approach to Moral Injury of Soldiers during WAR. International Journal of Military Affairs, 4(1), 20-25 (2019). [Article]
[11] Jones E. Moral Injury in Time of War. The Lancet, 391(10132), 1766-1767 (2018).
[12] Litz BT & Stein N & Delaney E & Lebowitz L & Nash WP & Silva C & Maguen S. Moral Injury and Moral Repair in War Veterans: A Pmodel and Intervention Strategy. Clinical Psychology Review, 29(8), 695-706 (2009).
[13] Drescher KD & Foy DW & Kelly C & Leshner A & Schutz K & Litz B. An Exploration of the Viability and Usefulness of the Construct of Moral Injury in War Veterans. Traumatology, 17(1), 8-13 (2011).
[14] Dombo EA & Gray C & Early BP. The Trauma of Moral Injury: Beyond the Battlefield. Journal of Religion & Spirituality in Social Work: Social Thought, 32(3), 197-210 (2013).
[15] Kim C. A Study on the Disaster Body Response Measurement System Using VR. International Journal of Human & Disaster, 6(3), 54-63 (2021). [Article]
[16] Lin K & Xia F & Li C & Wang D & Humar I. Emotion-aware System Design for the Battlefield Environment. Information Fusion, 47, 102-110 (2019).
[17] Hourani L & Tueller S & Kizakevich P & Strange L & Lewis G & Weimer B & Morgan J & Cooney D & Nelson J. Effect of Stress Inoculation Training with Relaxation Breathing on Perceived Stress and Posttraumatic Stress Disorder in the Military: A Longitudinal Study. International Journal of Stress Management, 25(1), 124-136 (2018).
[18] Jung B. Development of Evaluative Indicator of Safety Education for Korea Army. International Journal of Crisis & Safety, 3(1), 25-31 (2018). [Article]
[19] Baek S. A Study on the Improvement of Explosion Test on Blast-proof Door. International Journal of Military Affairs, 6(2), 11-20 (2021). [Article]
[20] Basu A & Aydin A. A Method for Normalization of Schmidt Hammer Rebound Values. International Journal of Rock Mechanics and Mining Sciences, 41(7), 1211-1214 (2004).
[21] Brencich A & Cassini G & Pera D & Riotto G. Calibration and Reliability of the Rebound(Schmidt) Hammer Test. Civil Engineering and Architecture, 1(3), 66-78 (2013).
[22] Kirkman E & Watts S. Characterization of the Response to Primary Blast Injury. Philosophical Transactions of the Royal Society B: Biological Sciences, 366(1562), 286-290 (2011).
[23] Malhotra A & Carson D & McFadden S. Blast Pressure Leakage into Buildings and Effects on Humans. Procedia Engineering, 210, 386-392 (2017).
[24] Mackenzie IM & Tunnicliffe B. Blast Injuries to the Lung: Epidemiology and Management. Philosophical Transactions of the Royal Society B: Biological Sciences, 366(1562), 295-299 (2011).
[25] Smith JE. The Epidemiology of Blast Lung Injury during Recent Military Conflicts: A Retrospective Database Review of Cases Presenting to Deployed Military Hospitals, 2003-2009. Philosophical Transactions of the Royal Society B: Biological Sciences, 366(1562), 291-294 (2011).
[26] Aboudara M & Mahoney PF & Hicks B & Cuadrado D. Primary Blast Lung Injury at a NATO Role 3 Hospital. British Medical Journal: Military Health, 160(2), 161-166 (2014).
[30] Gebbeken N & Döge T. Explosion Protection-architectural Design, Urban Planning and Landscape Planning. International Journal of Protective Structures, 1(1), 1-21 (2010).
[31] Barakat M & Hetherington JG & Autodyn. Architectural Approach to Reducing Blast Effects on Structures. Proceedings of the Institution of Civil Engineers-structures and Buildings, 134(4), 333-343 (1999).
[33] Lee JJ & Yun HS & Cho YJ & Park JH. Empirical Analysis of a Steam Explosion in a Slag Yard based on a Field Investigation and 3D Explosion Damage Simulation. Process Safety and Environmental Protection, 136, 126-135 (2020).
[34] Raj ST & Silan SL & Devgan VK. Structural Damage Analysis of Explosive Testing Experimental Bay Using Hexdam Modelling Software. Procedia Structural Integrity, 14, 395-402 (2019).
[28] Kim S & Oh K & Baek S & Lee J & Park Y & Baek J. Protective Structural Engineering. Cheong Moon Gak (2013).
[29] Krauthammer T. Modern Protective Structures. CRC (2008).
[27] Department of Defense. MIL-STD-1474D, Military Standard: Design Criteria Standard, Noise Limits (1997).
[32] http://www.breeze-software.com/ (2021).
[35] Raj ST & Silan SL & Kamal J. Hazard Assessment Modelling for the Target End Control Room of Penta Track Dynamic Trial Facility. International Conference on Range Technology (2019).
![](https://j-institute.com/wp-content/uploads/kboard_attached/1/202201/61dcfd27cdb543948967.png)
? Source: gasnews.com